TilingPlastering and renderingFloor levelingFinishingPrimersOther adhesivesWaterproofing and repairingTile GroutsUnmodified mixes
rus  |  eng
 

Base preparation

   The base surface should be strong, carefully cleared of dust, dirt, oils, and greases. Unstable and fragile parts of the base must be removed. Unevenness of a walls, a crack, and a recess should be pre-aligned with plaster IVSIL GROSS or IVSIL THINER. To correct uneven floors use one of self-leveling floors or screed IVSIL TIE-ROD. Before the faceworking surface should be primed with IVSIL OSNOVA. Strongly absorbing bases (gaze and foam concrete, gipsum plaster, anhydrite floor) should be primed with IVSIL GLUBOKOGO PRONIKNOVENIYA (primer penetrator).

Mixing of mortar

   Dry mix is poured into a mixing bucket with clean water in the following proportion: 1 kg of dry mix for 0,19-0,24 l of water. Then it is thoroughly stirred, manually or with a mixing drill, until the mixture is homogeneous and elastic. The mixture is left for 5 minutes and then stirred again. Prepared mixture should be used within 4 hours.

Application

   Adhesive solution is applied on basis with the help of a trowel and then is spread with a notched trowel. The size of notches depends on the size of a tile. Put a tile on the top of the mixture, which has just been applied, and press it to the surface. After being pressed, adhesive mixture should be covering not less than 65% of the tile’s surface.

   A tile must be laid within 10 minute from application of adhesive on the basis. Correction of the tile position can be done within 10 minutes after the tile is laid. There is no need to soak tiles in water before use.

   The air temperature and the temperature of the basis must be from +5° to +30°. Grouting of wall tiles can be done in 6-8 hours, grouting of floor tiles in 24 hours. All technical characteristics of the adhesive are fully active at the temperature of 18-20° and 60% humidity level.

 
Consultation on the pplication materials

FIX

  

   IVSIL FIX is a basic tile adhesive for decorating materials. It is economic and inexpensive, suitable for interior works with ceramic and porcelain tiles in dry and wet conditions, for wall and floor tilling & for external works. It is recommended as tile adhesive for tilling bathrooms, kitchens and any other premises with normal and high humidity.

   The benefit of using this material is that it is not expensive and you will need 10-12% less of this material per square meter as compared to a standard adhesive mix. It is recommended for laying tiles over mineral stable basis: concrete, brickwork, aerated and foam concretes, cement, cement-lime and gypsum plasters, cement, gypsum and anhydrite floors.

   The basic wholesale price of IVSIL FIX tile adhesive in Moscow and its area is 145 roubles. To find the prices of other tile adhesives, please visit the section «Price List».

   Low consumption of tile adhesive + economical price = tile adhesive IVSIL FIX.

   Please see also multipurpose frost resistant tile adhesive IVSIL START or go to the section all IVSIL TILE ADHESIVES

Economical, humidity resistant tile adhesive, tile adhesive with economical low consumption IVSIL FIX

 
 

Technical characteristics

Mixing proportion: 1l of water
On 1 kg of a mix0,19 - 0,24 l
On 25 kg of a mix4,75 - 6,00 l
The consumption at a thickness of a layer of 1 mm, on 1 sq. m1,2 1,4 kg
Thickness of a layer of a solution, mm2 6 mm
Viability of a solution4 hours
Open operating time10 min
Updating time10 min
Finish of seams24 hours
Temperature of works and the baseFrom +5 to +30
Adhesive strength0,5 MPa
Frost resistanceF35
Packaging25 kg bag
 
Packaging and storage
The dry adhesive mix is delivered in Craft-bags on 25 kg. A storage warranty period in a dry premise in packaging materials of the manufacturer is 12 months from the date of the manufacturing, specified in packing.
The consumption
Average consumption of a dry mix of 1,2 1,4 kg on 1 m2 surfaces at a thickness of a layer of a solution 1mm. Practically the consumption depends on degree of flatness of the base, size of a teeth of a spatula and a sort of an applied tile.
 
Home Search and map
Rambler's Top100
Site development —
the Internet-agency «Webstroy»